TM 5-3820-205-10-1
B-BEFORE
D-DURING
A-AFTER
W-WEEKLY
M-MONTHLY
Item
NO.
INTERVAL
ITEM TO BE INSPECTED
PROCEDURE: CHECK FOR AND HAVE
REPAIRED, FILLED, OR ADJUSTED AS NEEDED.
EQUIPMENT IS NOT
READY/AVAILABLE IF:
B D A W M
CHECKS 21 THROUGH 24 ARE FOR
TRANSPORT OF EQUIPMENT
21
TIRES
·
Check for excessive wear, cuts, cracks, abrasions,
low or flat tires and proper tire pressure (100 psi),
IAW TM 9-2610-200-14.
22
AIRBRAKE SYSTEM
·
Visually check the air lines for cuts, cracks, or
broken lines.
Air system will not maintain air pressure.
23
DOLLY AND DRAWBAR
·
Visually check for cracks, or broken parts on
drawbar and fifth wheel lock area.
Drawbar/dolly cracked or broken.
Fifth wheel will not lock.
24
AIRBRAKE SYSTEM
·
Drain air tanks after use only.
Section IV. TROUBLESHOOTING PROCEDURES
33.
General
This section provides information useful in diagnosing and correcting unsatisfactory operation or failure of the roll
crusher, and its components. Each trouble symptom stated is followed by a list of probable causes of the trouble. The
possible remedy recommended is described opposite the probable cause. Any operational trouble beyond the scope of
the operator or crew must be reported to organizational maintenance.
34.
Engine Hard to Start or Will Not Start (Exhaust Smoke Present)
Probable cause
Possible remedy
Engine cranking speed low (below 150 rpm) ........ Check engine cranking rpm.
Clutch engaged .................................................... Disengage clutch.
Cold start aid needed ........................................... Use starting fluid (fig 36).
Fuel filter plugged ................................................ Replace fuel filter.
Air in the fuel system ........................................... Check for air in fuel. Tighten fuel connections and filter.
Fuel suction line restricted ................................... Check fuel line for restriction.
Intake air system restricted .................................. Check intake air system for restrictions.
Fuel contaminated ............................................... Verify by operating engine from a temporary supply tank.
35.
Engine Cranks But Will Not Start (No Smoke From Exhaust)
Probable cause
Possible remedy
No fuel in tank ...................................................... Add fuel.
Fuel tank shut-off valve closed ............................ Open shut-off valve.
No fuel to injectors ............................................... Loosen fuel supply line between fuel pump and cylinder head while
cranking engine, and check for fuel (fig. 42)
37
